Technical Description of OBD-II Trouble Code
Malfunction in the Circuit of the Exhaust Gas Temperature (EGT) Sensor for Bank 1 Sensor 1
What does that signify?
This is a generic code that applies to all makes and models manufactured from 1996 onwards. However, the specific troubleshooting steps may vary depending on the vehicle.
The diagnostic trouble code (DTC) P0544 indicates a problem with the EGT (exhaust gas temperature) sensor located in the “up” pipe before the catalytic converter. Its main purpose is to protect the converter from damage caused by excessive heat.
Code P0544 indicates a general malfunction in the EGR temperature sensor circuit for bank 1, sensor #1. This DTC is associated with Bank #1, which is the side of the engine containing cylinder #1. Related codes include P0545 (circuit low) and P0546 (circuit high).
An EGT sensor is present in most modern gas or diesel engines. It is essentially a heat-sensitive resistor that converts the exhaust temperature into a voltage signal for the computer. One wire receives a 5-volt signal from the computer, while the second wire serves as the ground.
As the exhaust temperature increases, the resistance to ground decreases, resulting in a higher voltage. Conversely, as the temperature decreases, the resistance increases, leading to a lower voltage. If the engine detects a low voltage, the computer will adjust the engine’s timing or fuel ratio to maintain an acceptable temperature within the converter.
In a diesel engine, the EGT is used to determine the timing of regeneration of the diesel particulate filter (DPF) based on the temperature rise.
If a catless up pipe is installed and the catalytic converter is removed, there is usually no provision for the EGT sensor, or if there is, it will not function correctly without back pressure. This will trigger the code.
Symptoms
The check engine light will illuminate, and the computer will store the code P0544. No other noticeable symptoms will be present.
Potential Causes
The possible causes for this DTC may include:
Repair Procedures
Another reason for this code to be triggered is if the catalytic converter has been replaced with a catback system. In most states, this is an illegal procedure that can result in a significant fine if caught. It is advisable to check local and state laws regarding the removal of this system, as it leads to uncontrolled emissions into the atmosphere. While this may temporarily resolve the issue, it is our responsibility to contribute to keeping the atmosphere clean for future generations.
Until this issue is repaired, the code can be reset by purchasing a 2.2 ohm resistor from any electronic store for a minimal cost. Simply remove the EGT sensor and plug the resistor into the engine side electrical connector. Secure it with tape, and the computer will recognize that the EGT is functioning properly.